Goodman 3.5 Ton 15.2 SEER2 80000 BTU 80% Gas Furnace With R32 Air Conditioning Condenser And Coil System – Upflow
Check current price on AC Direct →
Key features
- 3.5-ton cooling capacity for homes roughly 1,800 to 2,400 sq ft (climate dependent)
- 15.2 SEER2 efficiency rating meets current federal minimums with room-temperature savings over older systems
- 80,000 BTU 80% AFUE upflow gas furnace included as a matched system bundle
- R-32 refrigerant with lower global-warming potential than outgoing R-410A
- Upflow configuration suits basement, utility room, or closet installs where air discharges upward
- Factory-matched coil and condenser simplify equipment selection and help preserve manufacturer warranty
About this system
This Goodman bundle pairs a 3.5-ton, 15.2 SEER2 R-32 air conditioning condenser and matching evaporator coil with an 80,000 BTU, 80% AFUE upflow gas furnace. The combination is sized for homes roughly in the 1,800 to 2,400 square foot range, depending on climate zone, insulation quality, and ceiling height. R-32 refrigerant carries a lower global-warming potential than the R-410A it replaces, and is increasingly the industry standard going forward, so this system is positioned well for the near-term regulatory environment.
At 15.2 SEER2, this system clears the federally mandated minimums for most U.S. regions and sits in the baseline-efficiency tier. It will deliver real operating cost savings compared to aging 10 to 13 SEER equipment, but homeowners in high-cooling climates or those chasing the lowest possible utility bills should weigh whether stepping up to a 17 or 18 SEER2 system pencils out over time. The 80% AFUE furnace is a standard single-stage unit suited to moderate heating climates. Buyers in very cold regions or those prioritizing heating efficiency should consider whether a 96% AFUE two-stage or modulating furnace is a better long-term fit before committing to this bundle.
This Goodman bundle is a competent, budget-conscious entry point for homeowners who need to replace aging equipment without paying premium-brand prices. The 15.2 SEER2 efficiency and 80% AFUE furnace are functional but not exceptional, and long-term ownership costs depend heavily on how well it is installed and maintained. Buyers who can absorb a higher upfront cost should at least price a step-up efficiency tier before deciding.
Overall score is the average of the five ratings above.
What we like
- Priced roughly 15 to 25 percent below comparable Trane, Lennox, and Carrier bundles
- R-32 refrigerant aligns with current industry direction and has a lower environmental footprint than R-410A
- Factory-matched coil and condenser simplify sizing decisions and support warranty compliance
- 15.2 SEER2 delivers meaningful efficiency gains over equipment rated 10 to 13 SEER
- Wide national dealer and parts network makes finding service technicians straightforward
Trade-offs
- Dual-run capacitors are the most commonly reported failure point, typically appearing after several years of use
- Evaporator coil leaks show up in a notable share of owner reports and can be costly to address
- Compressor longevity tends to average 10 to 14 years versus 15 to 20 for premium-brand compressors
- 80% AFUE furnace leaves meaningful efficiency and operating-cost gains on the table compared to 95%+ units
What homeowners and pros say about Goodman
Homeowners who review Goodman equipment on consumer channels tend to split into two camps: those who got a solid install and are still running the same system a decade in, and those who ran into repair costs that made them question the initial savings. Goodman’s ConsumerAffairs score sits at roughly 2.5 out of 5, though that platform draws disproportionately from frustrated owners, and the recurring pattern in those complaints is repair bills that start climbing after year seven or eight. Google dealer reviews tell a more balanced story at around 3.8 out of 5, where affordability is consistently the top reason buyers chose Goodman in the first place.
HVAC technicians who work on Goodman equipment regularly point to dual-run capacitors as the most predictable failure, which is not catastrophic since it is a relatively inexpensive fix, but it does mean budgeting for at least one service call in the equipment’s life. More consequential are evaporator coil leaks, which appear in enough owner reports to be worth factoring into a long-term cost comparison. Compressor life on Goodman units tends to average 10 to 14 years based on field experience, meaningfully shorter than the 15 to 20 years more commonly seen with Trane, Lennox, or Carrier compressors. A minority of owners also report refrigerant issues in the first year, which technicians typically attribute to install or initial charge problems rather than a manufacturing defect. The consistent takeaway from pros is that Goodman’s ceiling is set largely by whoever puts it in.
Sources: ConsumerAffairs Goodman owner reviews, AHRI Directory of Certified Product Performance, U.S. DOE appliance and equipment efficiency standards, Goodman product specification sheets.
What it costs to run
At 15.2 SEER2, cooling this 3.5-ton system for a typical 1200-hour cooling season at the U.S. average electricity rate of $0.17/kWh works out to roughly $564 per year in cooling, about $75 less per year than a minimum-efficiency 13.4 SEER2 unit of the same size. Your real cost depends on your climate and local rate.
Method: (42,000 BTU/hr ÷ 15.2 SEER2) × 1200 hours ÷ 1000 × $0.17/kWh. Rate source: U.S. EIA average; cooling hours: moderate-climate estimate.
How it compares
| Brand | Comparable model | SEER2 | Stage | Price position |
|---|---|---|---|---|
| Goodman | 3.5 Ton 15.2 SEER2 / 80K BTU 80% AFUE Bundle (this system) | 15.2 | Single-stage | Value pick |
| Carrier | Comfort 24ACC636 / 58CVA080 Bundle | 15.2 | Single-stage | Typically 15 to 25 percent more than this Goodman bundle |
| Trane | XR15 / S8X1 Bundle | 15.0 to 16.0 | Single-stage | Typically 20 to 30 percent more than this Goodman bundle |
| Lennox | Merit ML15 / ML196E Bundle | 15.2 to 16.0 | Single-stage | Typically 20 to 30 percent more than this Goodman bundle |
Competitor rows are comparable single-stage units at similar efficiency; price is relative position, not a quote.
Questions about this system
Will 3.5 tons be the right size for my house?
Sizing depends on your climate zone, insulation, window area, and ceiling height, not square footage alone. A Manual J load calculation by a licensed HVAC contractor is the only reliable way to confirm 3.5 tons is correct. Oversizing causes short-cycling and excess humidity; undersizing means the system runs constantly on the hottest days.
Is R-32 refrigerant safe, and will my technician be able to service it?
R-32 is mildly flammable (A2L classification) but is widely used globally and is becoming the U.S. industry standard. Most certified HVAC technicians are already trained to handle it, and parts availability is growing quickly. Confirm your contractor is familiar with A2L refrigerants before booking the install.
What warranty comes with this Goodman bundle?
Goodman typically offers a 10-year parts limited warranty when the equipment is registered within a set window after installation. The compressor usually carries its own 10-year limited coverage. Failure to register on time, or having the unit installed by an unlicensed contractor, can reduce coverage, so read the warranty terms carefully before your install date.
How concerned should I be about the evaporator coil leak and capacitor failure issues mentioned in owner reviews?
Dual-run capacitor failures are relatively common on Goodman equipment but are also one of the cheapest HVAC repairs, generally running 300 to 600 dollars. Evaporator coil leaks are more serious and more expensive. An annual maintenance visit where the technician checks refrigerant charge and inspects the coil is the best way to catch problems early.
Why is this furnace rated 80% AFUE instead of 95% or higher, and does that matter?
An 80% AFUE furnace converts 80 cents of every dollar of gas into heat; a 96% unit converts 96 cents. The difference adds up meaningfully over a heating season, especially in colder climates. If your home is in a region with long winters or high gas prices, pricing a high-efficiency furnace bundle before committing to this one is worth the time.
Specifications
| Cooling capacity | 3.5 Ton |
| Efficiency | 15.2 SEER2 |
| Furnace output | 80000 BTU |
| Configuration | Upflow |
| Refrigerant | R-32 |